As I mentioned in my Terminator themed T8 blog, I’ll be back. And now I’m back to let you know how the roll out of our T8 retrofit program is going. Since that original blog *checks watch* three years ago (!) we have replaced huge numbers of lamps throughout UHN, so this is a story that all sites can celebrate! Here are some quick numbers for lamps retrofitted at each site:
- TGH – 5,500
- TWH – 6,000
- PMH – 6,500
- TRI – 2,000
Total UHN: 20,000 lamps!
For those that are wondering what I’m talking about when I say “LED T8 tube” check the image below. The 8 refers to the diameter of the lamp in eighths of an inch (eight eighths is one inch).
So far, we have primarily installed new LED tubes in 24 hour applications, such as lobbies, hallways, stairwells, mechanical spaces, etc. The long run hours of these lamps mean that we are savings lots of energy and getting a faster payback.
UHN-wide savings total almost 1,500,000 kWh based on the 20,000 T8 lamps replaced. This is equivalent to the electricity consumption of 155 houses in Ontario!
Other Benefits of LED
Light Levels: In certain hallways at TGH, people were asking if the walls had been painted. This is because the LED lamps produce slightly more light than the old fluorescent lamps, enhancing hallway appearance and safety in previously under lit areas. We recognize that higher light output is not always desired and are also purchasing lower wattage T8s for sensitive areas.
Shatterproof: The LED lamps are made of a shatterproof plastic material, meaning they are safer to install and service than glass fluorescent tubes.
No Mercury: Old fluorescent lamps use mercury, a highly toxic substance, as a key component to make the lamp function. If a fluorescent lamp were to break, the mercury would escape and risk exposure to building occupants. LEDs have no mercury or any materials that can be released into the air. They are considered to be electronic waste, however, and must still be disposed of appropriately.
Longer service life: Fluorescent lamps have a typical service life of 20,000 hours and tend to degrade in performance and colour throughout their life. The LEDs installed have 50,000 hour life and new ones we are now purchasing have 70,000 hour lifespans. This extended life will free up some of our maintenance staff time that is spent changing light bulbs so that they can work on important tasks, such as preventive maintenance.
Since our original T8 supply contract, costs of LEDs have dropped almost in half and we have a new contract in place. Additionally, the LED lamps are now only 15W instead of the original 18W, while maintaining the exact same light output. With the lower cost of purchase and increased energy savings, it is now very cost effective to replace lamps not only in 24 hour areas, but in all areas. We are aggressively pursuing more replacements across UHN, including the following projects that are underway:
- TRI: 2,100 lamps (including relamping all T8s in Lyndurst and Rumsey Centre)
- TGH: 5,000 lamps
- KDT: 9,000 lamps (relamping the entire building)
I would like to thank the facilities teams who have worked hard to make these projects a success, especially at TRI and TGH, where facilities staff have done all the relamping work in house. Bravo!